Go Back   Ducati 1299 Forum > Ducati Panigale Forum > Guides

Guides How-To Guides for the Ducati 1299, 1199, 899


Thanks Tree37Thanks
Reply
 
LinkBack Thread Tools Display Modes
Old May 27th 2013, 02:12 PM   #1
Senior Member
 
Cobra700's Avatar
 
Joined: Sep 2012
From: Florida

Posts: 543
Thanks: 170

HOW TO: MWR Air Filter Install

Tools needed:

•3mm Allen wrench
•4mm Allen wrench
•5mm Allen wrench
•8mm socket
•Ratchet
•Cutters (To cut a zip tie)

Remove the key guard using a 4mm Allen for the 2 bolts closest to the key cylinder and a 3mm Allen for the 2 outside bolts.


Will look like this:


Remove the 2 5mm bolts on the sides that hold the tank down.


Remove the sleeve where the bolt went into.


Remove your seat using a 3mm Allen.


Now remove that bracket using a 8mm socket and ratchet and 4mm Allen.


Carefully pull off this wire.


Carefully pull up on the bottom of the tank and disconnect the fuel pump connector. It's one of those easy squeeze connectors.


Now to remove the tank I HIGHLY reccomend you have someone give you a hand so you don't scratch it up. (Thanks mom! Lol)
Have someone gently pull-up on the tank. Not too far because you still have to disconnect 2 hoses on the right of the tank. Patience is key. Not much room.


After those are disconnected lift the tank a little more so you can reach the fuel line. It is a quick connector. Just push down in the middle where the "button" is and it should pop right off. Just a tiny bit of fuel will drip. Set your tank in a safe place.


Now you'll be looking at this:


Now you want to carefully unplug the injectors. There is a ziptie holding the top injector wire. Very carefully cut the ziptie off. The injectors are the normal squeeze type plugs. Located here:


And here:


Next disconnect the fuel line at the "T" fitting. Push the 2 buttons on each side and carefully pull the fuel line out of the fitting.


Now there is a spring type clip on each of the throttle bodies. Easy to see on the top throttle body. A lil hard to get to on the front throttle body. Uncoil these so you can pull out the injectors and fuel line out. Gonna look like this:


Now you'll have plenty of room to remove the air filter.


Reach in there, push the air filter clips in and gently pull the filter out.


After the filter is out you might have a lil bit of sand/dirt/leaves/bugs or whatever in the airbox. Now is the time to carefully clean it out and being careful not to drop anything in your throttle bodies.

And here is the sexy MWR HE filter. Too bad it's hidden in the airbox.




Now it's going to be a tight fit but it will obviously go in. I took off the rubber seal around the airbox so I wouldn't accidentally mess it up. Just slide the filter in and push in on the legs to get it in the airbox.


Make sure it's seated in right and put everything back together reverse of removal.




ENJOY!!!
Thanks from Montfort, AntiHero, Frosty and 21 others

Last edited by Cobra700; May 27th 2013 at 03:08 PM.
Cobra700 is offline  
 
Old May 27th 2013, 03:18 PM   #2
Member
 
Joined: Feb 2012
From: So Cal

Posts: 92
Thanks: 3

I Ride: 1199, 848r
Thanks for the write up and pics
snake9 is offline  
Old May 27th 2013, 03:24 PM   #3
Senior Member
 
gnance's Avatar
 
Joined: Apr 2012
From: Longview

Posts: 485
Thanks: 170

I Ride: 2012 1199S ABS
Thanks!
gnance is offline  
Old May 27th 2013, 03:35 PM   #4
Senior Member
 
Castor Troy's Avatar
 
Joined: Jan 2013
From: Tampa Bay area

Posts: 415
Thanks: 101

I Ride: '14 ZX10R ABS/'12 Panigale S w/ABS
Idles better now?
Castor Troy is offline  
Old May 27th 2013, 03:37 PM   #5
Senior Member
 
flobrandx's Avatar
 
Joined: Jun 2012
From: PNW

Posts: 2,792
Thanks: 1313

I Ride: 2010 RSV4 Factory (Track), Paul Smart LE, 1199 Panigale S Tricolore (SOLD)
Nice! Thanks Cobra!
flobrandx is offline  
Old May 27th 2013, 04:13 PM   #6
Senior Member
 
EvoL's Avatar
 
Joined: Feb 2013
From: Tampa, FL

Posts: 1,043
Thanks: 445

I Ride: 1199 R
Impressions? Nice write up!
EvoL is offline  
Old May 27th 2013, 04:53 PM   #7
Phl
Moderator
 
Phl's Avatar
 
Joined: Feb 2012
From: here

Posts: 6,948
Thanks: 3598

I Ride: Panigale, CRF450, FZR400, GROM
mine are so far: smooth idle and pull from very low revs. my difference might be less as i am running a 14 T front sprocket.

also the sound higher up is "quite nice", as it seems to pull a little harder ... ?
Thanks from Castor Troy and JeffD
Phl is offline  
Old May 27th 2013, 07:50 PM   #8
Senior Member
 
Joined: Apr 2013
From: Lake Mary, FL

Posts: 1,818
Thanks: 875

I love people who do these types of things for other forum members. Thanks Phil and Cobra700!
Thanks from SeerreuS
JeffD is offline  
Old May 29th 2013, 12:35 PM   #9
Banned
 
mark419ny's Avatar
 
Joined: May 2012
From: South Florida

Posts: 4,971
Thanks: 1811

I Ride: 2012 1199s 2014 HP4 2007 zx6r (track)
thanks i had a hard time with my first install (not my bike) but will try this way for sure this weekend.
Thanks from Gunny Fitz
mark419ny is offline  
Old May 29th 2013, 02:47 PM   #10
Senior Member
 
Cobra700's Avatar
 
Joined: Sep 2012
From: Florida

Posts: 543
Thanks: 170

Originally Posted by Castor Troy View Post
Idles better now?
Originally Posted by EvoL View Post
Impressions? Nice write up!
Seems like Idle is a lil smoother and more "sucking sound" on top end. Possibly feels a lil more responsive but I dunno if I'm trying to feel it lol!
Should be getting a dyno tune soon so hopefully it'll help
Thanks from bradp51, Gunny Fitz and Castor Troy
Cobra700 is offline  
Reply

  Ducati 1299 Forum > Ducati Panigale Forum > Guides

Tags
air, filter, install, mwr



Search tags for this page
Click on a term to search for related topics.
Thread Tools
Display Modes


Similar Discussions
Thread Thread Starter Forum Replies Last Post
MWR air filter du11co Mechanical and Technical 4 Mar 29th 2013 09:32 PM
Oil Filter Cover - Correct Install Xbox Mechanical and Technical 5 Sep 23rd 2012 08:26 AM
oil filter? BlueBear Mechanical and Technical 1 Aug 19th 2012 05:29 PM
air filter install stu1199 Ducati 1199 0 Aug 16th 2012 12:36 PM
Oil FIlter TransNone13 Ducati 1199 4 May 12th 2012 10:04 AM


Facebook Twitter Google+ RSS Feed